Vertical board staples - Escape Trailer Owners Community
Journey with Confidence RV GPS App RV Trip Planner RV LIFE Campground Reviews RV Maintenance Take a Speed Test Free 7 Day Trial ×

Go Back   Escape Trailer Owners Community > Escape Tech > Problem Solving | Owners helping each other
Click Here to Login
Reply
 
Thread Tools Display Modes
 
Old 05-30-2016, 11:04 PM   #1
Senior Member
 
Carla Jean's Avatar
 
Join Date: Sep 2014
Location: Port Townsend, Washington
Trailer: Escape 21' 2016
Posts: 228
Vertical board staples

The vertical board on the right side in the cupboard over the wheel well below the furnace in our 2016 21' has separated from the front board. I will try and upload my photos.
Attached Thumbnails
image.jpg  
__________________
Carla Jean Pugh (and my guy, Ned)
"Pepé Le Pugh"
2016 Escape 21'
2005 Toyota 4Runner
Carla Jean is offline   Reply With Quote
Old 05-30-2016, 11:35 PM   #2
Senior Member
 
Greg A's Avatar
 
Join Date: Oct 2013
Location: Phoenix, Arizona
Trailer: 2015 Escape 19 "Seventy Degrees"
Posts: 3,495
Brand new trailer to boot. Sounds like ur off to Chilliwack with this and the shower issue. At least ur close by.
Greg A is offline   Reply With Quote
Old 05-31-2016, 01:15 AM   #3
Senior Member
 
Ron in BC's Avatar
 
Join Date: Jan 2014
Location: North Van., British Columbia
Trailer: 2014 Escape 19, sold; 2019 Escape 21, Sept. 2019
Posts: 8,744
There's not much holding it in to begin with. I pulled a similar piece in mine out with my fingers without damaging it. Just a few small staples and a couple of dabs of glue.

Ron
Ron in BC is offline   Reply With Quote
Old 05-31-2016, 10:14 AM   #4
Senior Member
 
Carla Jean's Avatar
 
Join Date: Sep 2014
Location: Port Townsend, Washington
Trailer: Escape 21' 2016
Posts: 228
Quote:
Originally Posted by Ron in BC View Post
There's not much holding it in to begin with. I pulled a similar piece in mine out with my fingers without damaging it. Just a few small staples and a couple of dabs of glue.

Ron
I assume that the heater will have to be removed in order to repair it?? I will send the picture to ETI to get their opinion. Thanks, Ron.
__________________
Carla Jean Pugh (and my guy, Ned)
"Pepé Le Pugh"
2016 Escape 21'
2005 Toyota 4Runner
Carla Jean is offline   Reply With Quote
Old 05-31-2016, 11:44 AM   #5
Senior Member
 
Join Date: Mar 2013
Location: North of Danbury, Wisconsin
Trailer: 2018 Escape 21C
Posts: 3,033
You could try and reattach the trim with short trim screws.
Drill some small holes in the trim and into the face frame then screw the trim in place with a battery drill and putty the holes .
The screws require a #10 tip and are hardened and coated for rust resistance. I use them when building cabinets or installing trim.
Much better than nails or staples because they do not work there way loose and you don't damage the trim or end up with hammer marks.
steve dunham is offline   Reply With Quote
Old 06-07-2016, 08:00 AM   #6
Senior Member
 
Join Date: May 2016
Location: Danville, Kentucky
Trailer: 1988 Bigfoot TF20 DLX Fifth Wheel
Posts: 100
Wow. On a virtually new camper...hummmmmm.
TheWanderers is offline   Reply With Quote
Old 06-07-2016, 08:43 AM   #7
Senior Member
 
Iowa Dave's Avatar
 
Join Date: Aug 2015
Location: Benton County, Iowa
Trailer: 2013 Escape 21 Classic Number 6, pulled by 2018 Toyota Highlander
Posts: 8,235
Quote:
Originally Posted by TheWanderers View Post
Wow. On a virtually new camper...hummmmmm.
I'm going to town to pick up a new good hard hat and a fresh can of negativity repellant. The sky is falling today, AGAIN.
Dave
Iowa Dave is offline   Reply With Quote
Old 06-07-2016, 09:16 AM   #8
Senior Member
 
Bobbito's Avatar
 
Join Date: Sep 2014
Location: Surrey, British Columbia
Trailer: 2015 Escape 21
Posts: 699
Vertical board staples

Welcome to the forum. Our own experience with trailers, plus talking with countless other owners, has convinced me you would be exceptionally lucky not to have a few minor issues to fix on a new trailer, even an Escape. We just stopped by ETI a week ago to get about 6 minor problems addressed on our year old Escape 21. We had more issues with our 2002 Nash trailer and more serious to boot (like discovering two years on that one of the 4 brakes had never been working due to a wiring issue and a hot water heater that always blew out in the wind). ETI has recently hired a fellow named Nigel with experience in Quality Management (in a big box store according to Tammy). I think they are on the right track, especially as they are expanding their operation. Nigel looked our trailer over for other possible issues based on their experience and found another minor issue they repaired during our 1 hour stay. (Lino joint by 21's furnace cabinet needed a cap strip). The huge difference between Escape and other manufacturers is the direct communication with their experts, including the owners/designers of the trailers. Oh, then there is the two year warranty, when most trailers come with only 1 year.

I worked in a hospital lab as a supervisor for 35 years and can tell you horror stories about the errors that occur with complex systems. I can just imagine how challenging it is to train staff to do a lot of different procedures in manufacturing these trailers and also cross training them to cover for illness and vacation. Despite ETI hiring a QM guy, there will always be problems, even with fairly new Escapes. Both our awning support handles had broken springs due to a bad batch. The hardware came from a reputable trailer awning manufacturer, but they clearly have quality issues. Sorry for the long-winded response. I see a lot of people who are surprised to have issues with a new trailer and decided to use your comment to address what I believe are unrealistic expectations and to share the news of ETI hiring Nigel.

Bob K


Sent from my iPhone using Tapatalk
Bobbito is offline   Reply With Quote
Old 06-07-2016, 09:18 AM   #9
Senior Member
 
thoer's Avatar
 
Join Date: Oct 2009
Location: Galesville, Wisconsin
Trailer: 2017 21 "Blue II" & 2017 Highlander XLE (previously 2010 17B "Blue" & 2008 Tacoma)
Posts: 4,232
Bob, very well said, and important insights.
__________________
Eric (and Mary who is in no way responsible for anything stupid I post)

"Beware of false knowledge; it is more dangerous than ignorance." George Bernard Shaw
thoer is offline   Reply With Quote
Old 06-07-2016, 10:23 AM   #10
Senior Member
 
Carla Jean's Avatar
 
Join Date: Sep 2014
Location: Port Townsend, Washington
Trailer: Escape 21' 2016
Posts: 228
We have an appt with ETI to repair this and they will do an outstanding job. We had minor issues with our past little fiberglass trailer, and we are fortunate that Tammy and Reace are so dang conscientious and back up any issues on their trailers. Not so with some other trailer companies....
__________________
Carla Jean Pugh (and my guy, Ned)
"Pepé Le Pugh"
2016 Escape 21'
2005 Toyota 4Runner
Carla Jean is offline   Reply With Quote
Old 06-07-2016, 10:30 AM   #11
Site Team
 
Donna D.'s Avatar
 
Join Date: Nov 2008
Location: Portland, Oregon
Trailer: 2014 Escape 5.0 TA
Posts: 11,023
Have you ever followed a travel trailer as it's going down the road? These things are like moving/jumping earthquakes. It's a wonder all the interior screws don't back out and the cupboard doors, etc. don't fall off. I'm just grateful when I get where I'm going the paper towels are still on the roll.
__________________
Donna D.
Ten Forward
2014 Escape 5.0TA
Donna D. is offline   Reply With Quote
Old 06-07-2016, 10:33 AM   #12
Senior Member
 
Bobbito's Avatar
 
Join Date: Sep 2014
Location: Surrey, British Columbia
Trailer: 2015 Escape 21
Posts: 699
Especially on some of the washboard roads we recently travelled, not to mention a speed bump I hit far too fast.


Sent from my iPhone using Tapatalk
Bobbito is offline   Reply With Quote
Old 06-07-2016, 10:56 AM   #13
Senior Member
 
Carla Jean's Avatar
 
Join Date: Sep 2014
Location: Port Townsend, Washington
Trailer: Escape 21' 2016
Posts: 228
Quote:
Originally Posted by Donna D. View Post
Have you ever followed a travel trailer as it's going down the road? These things are like moving/jumping earthquakes. It's a wonder all the interior screws don't back out and the cupboard doors, etc. don't fall off. I'm just grateful when I get where I'm going the paper towels are still on the roll.
You're absolutely right, Donna. I'm thinking that I need to rethink my storage options. (Or buy smaller booze bottles for that area...?)
__________________
Carla Jean Pugh (and my guy, Ned)
"Pepé Le Pugh"
2016 Escape 21'
2005 Toyota 4Runner
Carla Jean is offline   Reply With Quote
Old 06-07-2016, 04:46 PM   #14
Senior Member
 
Join Date: May 2010
Location: Missoula, Montana
Trailer: Escape 19, 2018: Last Best Escape
Posts: 395
Well said, Bob. Cars frequently, and houses generally, cost much more and often have significantly more issues. And it's the "standing behind the product" that distinguishes ETI.
__________________
2018 Escape 19: Last Best Escape
2015 Escape 19 (previous): Escape Goats
2011 Escape 17 (previous): SittEscape

Honda Pilot 2019
ksitte is offline   Reply With Quote
Old 06-07-2016, 05:04 PM   #15
Senior Member
 
PGDriver's Avatar
 
Join Date: Nov 2008
Location: Southern Alberta, Alberta
Trailer: 2015 Escape 5.0TA
Posts: 1,734
Quote:
Originally Posted by Carla Jean View Post
You're absolutely right, Donna. I'm thinking that I need to rethink my storage options. (Or buy smaller booze bottles for that area...?)


I would go with "rethink my storage options" Carla Jean.

Cheers
Doug
__________________
Cheers
Doug
PGDriver is offline   Reply With Quote
Old 06-07-2016, 11:47 PM   #16
Commercial Member
 
tractors1's Avatar
 
Join Date: Apr 2014
Location: Hillsboro, Oregon
Trailer: 2014 Escape 21 - "Felicity"
Posts: 2,945
Quote:
Originally Posted by Carla Jean View Post
You're absolutely right, Donna. I'm thinking that I need to rethink my storage options. (Or buy smaller booze bottles for that area...?)
Here ya go.
Attached Thumbnails
PICT0229 (2).jpg  
__________________
Charlie Y

Need custom storage to your design? Don't drill holes!
www.RVWidgetWorks.com
tractors1 is offline   Reply With Quote
Old 06-08-2016, 06:25 AM   #17
Senior Member
 
Jim Bennett's Avatar
 
Join Date: Oct 2008
Location: Calgary, Alberta
Trailer: 2017 Escape 5.0 TA
Posts: 15,532
Quote:
Originally Posted by Donna D. View Post
Have you ever followed a travel trailer as it's going down the road? These things are like moving/jumping earthquakes. It's a wonder all the interior screws don't back out and the cupboard doors, etc. don't fall off. I'm just grateful when I get where I'm going the paper towels are still on the roll.
This is so true, and one of the reasons that a hard shelled moulded fibreglass trailer will outlast a stick built one.
Quote:
Originally Posted by Carla Jean View Post
You're absolutely right, Donna. I'm thinking that I need to rethink my storage options. (Or buy smaller booze bottles for that area...?)
Are you crazy? Strike that second option of the list immediately.

I am sure you must have typed it in a moment of weakness.
__________________
2017 Escape 5.0 TA
2015 Ford F150 Lariat 3.5L EcoBoost
2009 Escape 19 (previous)
“Most folks are about as happy as they make up their minds to be.” — Abraham Lincoln
Jim Bennett is offline   Reply With Quote
Old 06-08-2016, 08:30 AM   #18
Senior Member
 
Carla Jean's Avatar
 
Join Date: Sep 2014
Location: Port Townsend, Washington
Trailer: Escape 21' 2016
Posts: 228
Quote:
Originally Posted by tractors1 View Post
Here ya go.
Nice, Charlie!
__________________
Carla Jean Pugh (and my guy, Ned)
"Pepé Le Pugh"
2016 Escape 21'
2005 Toyota 4Runner
Carla Jean is offline   Reply With Quote
Old 06-08-2016, 08:39 AM   #19
Senior Member
 
Jim Bennett's Avatar
 
Join Date: Oct 2008
Location: Calgary, Alberta
Trailer: 2017 Escape 5.0 TA
Posts: 15,532
Quote:
Originally Posted by tractors1 View Post
Here ya go.
That is a great solution for stabilizing heavy stuff.
__________________
2017 Escape 5.0 TA
2015 Ford F150 Lariat 3.5L EcoBoost
2009 Escape 19 (previous)
“Most folks are about as happy as they make up their minds to be.” — Abraham Lincoln
Jim Bennett is offline   Reply With Quote
Old 06-08-2016, 09:46 AM   #20
Senior Member
 
drpaddle's Avatar
 
Join Date: Apr 2014
Location: Gig Harbor, Washington
Trailer: Escape 21 'Toto'
Posts: 301
Carla Jean, if you downsize your bottles we can "store" the larger ones for you.
__________________
doug, sooz & the furfoots
www.followtoto.com
drpaddle is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off




» Featured Campgrounds

Reviews provided by

Disclaimer:

This website is not affiliated with or endorsed by Escape Trailer Industries or any of its affiliates. This is an independent, unofficial site.


All times are GMT -5. The time now is 09:43 AM.


Powered by vBulletin® Version 3.8.8 Beta 4
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
Copyright 2023 Social Knowledge, LLC All Rights Reserved.